Practical Operations Management
2nd Edition
ISBN: 9781939297136
Author: Simpson
Publisher: HERCHER PUBLISHING,INCORPORATED
expand_more
expand_more
format_list_bulleted
Concept explainers
Question
Chapter 5, Problem 3P
Summary Introduction
Interpretation: Type of suffering when volume of production increases cost of production.
Concept Introduction:
Diseconomies of scale:It is the level at which the average cost per unit of a product increases due to increase in production volume. This is a disadvantage to a service system. Hence, it is necessary for the service system to operate at the optimal level.
Expert Solution & Answer
Want to see the full answer?
Check out a sample textbook solution
Students have asked these similar questions
A fleet repair facility has the capacity to repair 800 trucks per month. However, due to scheduled maintenance of their equipment, management feels that they can repair no more than 600 trucks per month. Last month, two of the employees were absent several days each, and only 400 trucks were repaired.
Calculate the utilization of the repair shop.
Calculate the efficiency of the repair shop.
Discuss the utilization and efficiency of this repair facility. What can be done to improve the operations at the facility?
A restaurant considers changing the number of waiters during dinner hours.
There are currently seven waiters. It takes 70 minutes to serve a table on average. A new party (table) comes to the restaurant every 12.28 minutes.
The restaurant considers decreasing the number of waiters by 1, down to 6.
How much would the probability of walking into a completely busy restaurant increase when the number of waiters is 6 compared to 7?
I need typed answer don't write in a paper
A crew of mechanics at the Department of Transportation garage make minor repairs to snowplows during the winter. The snowplows break down at an average rate of 5 vehicles per day and breakdowns are distributed according to the Poisson distribution. The mechanic can service an average of 8 vehicles per day with a repair time distribution that approximates a negative exponential distribution. Assume an 8 hour day.
What are the chances that 3 vehicles are in the service system?
Group of answer choices
9%
38%
63%
19%
Chapter 5 Solutions
Practical Operations Management
Ch. 5 - Prob. 1DQCh. 5 - Prob. 2DQCh. 5 - Prob. 3DQCh. 5 - Prob. 4DQCh. 5 - Prob. 5DQCh. 5 - Prob. 6DQCh. 5 - Prob. 7DQCh. 5 - Prob. 1PCh. 5 - Prob. 2PCh. 5 - Prob. 3P
Ch. 5 - Prob. 4PCh. 5 - Prob. 5PCh. 5 - Prob. 6PCh. 5 - Prob. 7PCh. 5 - Prob. 8PCh. 5 - Prob. 9PCh. 5 - Prob. 10PCh. 5 - Prob. 11PCh. 5 - Prob. 12PCh. 5 - Prob. 13PCh. 5 - Prob. 14PCh. 5 - Prob. 15PCh. 5 - Prob. 16PCh. 5 - Prob. 17PCh. 5 - Prob. 18PCh. 5 - Prob. 19PCh. 5 - Prob. 20PCh. 5 - Prob. 21PCh. 5 - Prob. 22PCh. 5 - Prob. 23PCh. 5 - Prob. 24PCh. 5 - Prob. 25PCh. 5 - Prob. 26PCh. 5 - Prob. 27PCh. 5 - Prob. 28PCh. 5 - Prob. 29PCh. 5 - Prob. 30PCh. 5 - Prob. 31PCh. 5 - Prob. 32PCh. 5 - Prob. 33PCh. 5 - Prob. 34PCh. 5 - Prob. 35PCh. 5 - Prob. 36PCh. 5 - Prob. 37PCh. 5 - Prob. 38PCh. 5 - Prob. 1.1QCh. 5 - Prob. 1.2QCh. 5 - Prob. 1.3QCh. 5 - Prob. 1.4QCh. 5 - Prob. 2.1QCh. 5 - Prob. 2.2QCh. 5 - Prob. 2.3QCh. 5 - Prob. 3.1QCh. 5 - Prob. 3.2QCh. 5 - Prob. 3.3QCh. 5 - Prob. 3.4Q
Knowledge Booster
Learn more about
Need a deep-dive on the concept behind this application? Look no further. Learn more about this topic, operations-management and related others by exploring similar questions and additional content below.Similar questions
- A large city in the mid-West needs to acquire a street-cleaning machine to keep its roads looking nice year-round. A used cleaning vehicle will cost $85,000 and have a $20,000 market (salvage) value at the end of its five-year life. A new system with advanced features will cost $150,000 and have a $40,000 market value at the end of its five-year life. The new system is expected to reduce labor hours compared with the used system. Current street-cleaning activity requires the used system to operate 8 hours per day for 20 days per month. Labor costs $50 per hour (including fringe benefits), and MARR is 12% per year.]arrow_forwardA crew of mechanics at the Highway Department Garage repair vehicles that break down at an average of λ = 8 vehicles per day (approximately Poisson in nature). The mechanic crew can service an average of μ = 11 vehicles per day with a repair time distribution that approximates an exponential distribution. The crew cost is approximately $300 per day. The cost associated with lost productivity from the breakdown is estimated at $150 per vehicle per day (or any fraction thereof). What is the probability that there are more than two vehicles in the system?arrow_forwarda) Suppose you walk into a large supermarket at 2 am with a friend. Your friend says, "I can't believe that these stores stay open all night. Only one out of fifteen checkout lines is open. There can't be more than ten shoppers in this store. It just doesn't make any sense for this store to be open all night." What conditions must be true for it to be to the advantage of the supermarket to stay open all night? b) Your friend has a large garden and grows fresh fruit and vegetables to be sold at a local "farmer's market." Last year your friend was the only worker in the garden, without any additional workers. However, this year your friend hired a worker and production more than doubled. He comments "Next summer, I think I'll hire another two workers (so total workers including myself would go up from 2 to 4) and my output should again more than double". Is it likely that he could hire more workers and always continue to reap greater than proportional increases in production? Why?arrow_forward
- Flying against the wind, an airplane travels 3050 kilometers in 5 hours. Flying with the wind, the same plane travels 6060 kilometers in 6 hours. What is the rate of the plane in still air and what is the rate of the wind?arrow_forwardAn airline company has been contracting a maintenance company to do overhauls for its planes at a cost of $51275 per plane per quarter. The airline company estimates that by building a $1461838 maintenance facility with a life of 5 years and a residual market value of $770217 at the end of its life, they could handle their own overhaul at a cost of only $42020 per plane per quarter. What is the minimum number of planes they must operate to make it just profitable to build this facility? (=2% per quarter). • 25 O 31 Clear my choicearrow_forwardA series of thefts from your pharmacy area have occurred in the last six weeks. The director of security and the head of pharmacy services now require all persons working in the pharmacy department with access to drugs to clock out after their shifts and then go through a security check before leaving the building. Several employees have complained that they should be paid for this time because the security check is for the employer’s benefit. The director of security and the head of pharmacy services have responded that this security check is for the benefit of the employees to ensure that no one is unjustly accused. Is either party correct? If so, which one and why?arrow_forward
- A large food-processing corporation is considering using laser technology to speed up and eliminate waste in the potato-peeling process. To implement the system, the company anticipates needing $3 million to purchase the industrial-strength lasers. The system will save $1,200,000 per year in labor and materials. However, it will incur an additional operating and maintenance cost of $250,000 per year. Annual income taxes will also increase by $150,000. The system is expected to have a 10-year service life and a salvage value of about $200,000. If the company's MARR is 18%,justify the economics of the project using the PW method.arrow_forwardIn the production shop of a company, the breakdown of the machines is found to be Poisson distributed with an average rate of 3 machines per hour. Breakdown time at one machine cost 400 birr per hour to the company. There are two choices before the company for hiring the repairmen. One of the repairmen is slow but cheap, the other is fast but expensive. The slow cheap repairman demands 200 birr per hour and will repair the broken down machines exponentially at the rate of 5 per hour. The fast expensive man demands 300 birr per hour and will repair machines exponentially at an average rate of 6 per hour. Which repairman should be hired?arrow_forwardAre service operations with a high degree of customer contact more or less difficult to control than those with a low degree of customer contact?arrow_forward
- If a 500-room resort generated a TREVPAR of $200’000 (on annual basis), an occupancy of 80% and its dollars per guest day is $400, what is its multiple occupancy %?arrow_forwardA single server queuing system with a Poisson arrival rate and exponential service time has an average arrival rate of 9 customers per hour and an average service rate of 13 customers per hour. The probability of 6 customers in the system is : a. 0.9661 b. 0.8899 c. 0.3077 d. 0.03388arrow_forwardDescribe at least two measures that can be implemented in order to minimize the risk of downtime. Be specific and provide detail on how the measure works and specifically what risk it reduces related to system downtime.arrow_forward
arrow_back_ios
SEE MORE QUESTIONS
arrow_forward_ios
Recommended textbooks for you
Practical Management ScienceOperations ManagementISBN:9781337406659Author:WINSTON, Wayne L.Publisher:Cengage,
Practical Management Science
Operations Management
ISBN:9781337406659
Author:WINSTON, Wayne L.
Publisher:Cengage,